11
Jun
As a result golf cart battery chargers for 48 volt Club Cars need a working OBC to get them to start charging. These reconfigured kits have bottles that include comfortably integrated handholds making them easy to grip with gloves have larger square openings allowing for quick filling without removing bottom lid as well as an even flow of sand to fill divots more effectively.
Yamaha uses rechargeable acid-based batteries in its golf carts.
Troubleshooting electric golf carts. Today well look at the most common problems with electric golf carts and how you can prevent or repair them. Batteries That Break Down or Lose Charge. If your golf cart wont start the first thing we suggest it checking your battery.
Electric golf cart batteries need to be charged and have water added regularly. Test the wall socket where you charge your cart. Every golf cart has a built-in charger that connects to a wall socket.
Take your wall socket 120-volt tester and check the actual socket that you use to charge the cart itself. Plug in your 120-volt tester and make sure the actual wall socket is good. There are many different systems to consider when troubleshooting your electric golf cart motor.
The motor is the last in a series of components that could fail. After determining that the carts batteries and charger are working properly you can reset the motor to see if it runs. You must replace the motor if it has burnt out.
A common golf cart part that often needs repair on an electric golf cart is the cord to your golf cart charger. Bring the charger in to your local dealer for testing and for about 100 the cord can be replaced. Public Golf Courses Best Golf Courses Golf Cart Parts Golf Carts.
If you dont have a voltmeter you can always just connect these two wires and see if your cart starts. This is called hotwiring we wrote an article about it. If the switch fails the test or if your cart works without the switch then replace the switch as soon as you can.
Hot wiring your golf cart is bad for it. Verify that your golf cart transmission is fully in the Park position when not being operated. Some electrical issues found in E-Z-GO golf carts arise from the transmission selector switch not being placed fully in the correct position for the desired means of transportation.
Most golf carts are either 36 volts or 48 volts. The voltage will usually be written on the side of the solenoid. Troubleshooting a Solenoid Using a Voltmeter Using Continuity Instead of Ohms Troubleshooting Solenoid on 1987 Club Car.
EZGO Golf Cart Electric Motor Troubleshooting Table For all your electrical motor issues please match the symptoms to the probably cause. This will allow you to correct the problem with your EZ GO goft cart electric motor. EZGO Golf Cart Brakes Troubleshooting Flow Chart.
First connect the voltmeter to the controller and the battery. Connect the voltmeter to the M terminal of the speed controller and the negative terminal of the cart battery. Now push on the cart pedal and check the full battery voltage.
As soon as the full voltage is shown push the entire pedal down. First off if your controller is bad your vehicle wont run. However there are other reasons that could lead to your vehicle not running.
Here are a few quick troubleshooting tips. Make sure it isnt your batteries. If your batteries are old and dead then your golf cart will not operate.
As a result golf cart battery chargers for 48 volt Club Cars need a working OBC to get them to start charging. So it is possible that your OBC is malfunctioning and it is not the golf cart charger. Again this is only for 48 volt Club Car golf carts Not for Yamaha or EZGO golf carts.
Make sure the golf cart is either in forward reverse or neutral and not anything in between as this will interrupt the electrical flow and give you the wrong readings. Check the ignition wire that runs from your ignition to the solenoid starter. See if there is any corrosion or damage to it.
Check your tire pressure to be sure it is at the proper level. E-Z-Go electric carts with low tire pressure will experience an increased load on the batteries which will slow you down and decrease the distance you can drive before recharging. Inflate tires to 18 to 22 PSI.
The most common problem with Yamaha golf carts is with the battery. Yamaha uses rechargeable acid-based batteries in its golf carts. If your battery is giving you trouble make sure the terminals are clean and secure.
You can use a mixture of water and baking soda to clean them. The E-Z-GO golf cart has two kinds of speed controllers the Precision Drive System PDS and the Drive Control System models before 1994. If your cart is having problems running at a constant speed or is performing erratically then you should troubleshoot the controller to find out what the problem is.
Yamaha Sand Bottle Kits. Always have sand on hand with our updated sand bottle kits. These reconfigured kits have bottles that include comfortably integrated handholds making them easy to grip with gloves have larger square openings allowing for quick filling without removing bottom lid as well as an even flow of sand to fill divots more effectively.
Golf Cart accessories and parts for all your needs. Items are in stock and ready to ship. Call us toll-free 7 days a week.
1-888-444-9994 Where the cart is just the start.